Fluid was leaking from the gear box. That will depend on which Tranny you have there were 2 see links below. Note: all capacities are approximate. The cover is part no. I also had to remove the neutral switch assembly in which I broke trying to unplug the wiring harness. When adding, be sure to fill to the appropriate level, as recommended in user manual for your Chevrolet Silverado 2003.
Complaint Number: 10169881 Incident Date: July 15, 2006 Date Added to File: October 3, 2006 Description of the Complaint: I had the transmission fluid flushed and filter changed and the mechanic tells me there was a lot of metal particles in the transmission fluid and felt there was an impending failure. That set-up provided a brawny, segment-leading 365 horsepower and 660 lb. Standard for the 2500 is a solid Vortec 6. Low Transmission Fluid Signs Transmission Not Locking in Overdrive The 4L60E and 4L80E both have torque converters that lock. Your car's manual provides transmission fluid service requirements.
Check fluid level and add fluid as needed. This site is intended for reference only. Categories Tags , , , Post navigation. Due to the heat generated in the transmission, the fluid can break down over time. My Tahoe has a deep pan which required a different filter. First make sure you can remove the shift linkage from the side of the transmission.
In addition to the above: I couldn't gain access to the Torx bolts securing the cable bracket. Hint, the amount that comes out is pretty close to what you'll need to put back in. The second row seat belt was inoperative. It is held from above by two torx head cap screws. This is the response I got from three dealerships. It came in the lighter duty trucks.
The battery was replaced because it would not hold a charge. Check fluid again and top off as necessary. Built to tow 13,000 pounds, the Chevy 2500 has a maximum towing capacity of 16,700 pounds when equipped with a fifth-wheel hitch. One end is deeper than the other end. The water pump gasket and lower radiator hose was leaking. .
The front hub assembly has also gone out twice on this truck. Little towing done with the vehicle so that is not the cause. I've also had my air conditioning go out twice and is nearing failure again. Install the new seal, filter and replace the pan when it is completely done draining. The fuel filter was replaced.
The tires were replaced, however months later one of the tires developed a slow leak, due to a pin hole located in the sidewall. Or, you can go to any of the troubleshooting guides for these transmissions: 4L60E Transmission Problems Check Engine Light Before doing any serious work, if you have a check engine soon light, go ahead and have it scanned to see what trouble codes it is throwing out. If you want to change engine oil, for instance, by yourself and save a couple of bucks you need to know how much this fluid engine oil is needed for Chevrolet Silverado 2003. You should want this to be the problem. Found defect while backing it out of driveway; the back cover of the transmission was cracked and fluid coming out. A two hour job turned into 8 hours plus 4 trips to a parts store for tools and parts. The check engine light illuminated.
You can share this information with your friends Copyright © 2012-2019,. Complaint Number: 10231046 Incident Date: April 10, 2005 Date Added to File: June 15, 2008 Description of the Complaint: My 2003 chevrolet 2500hd truck has had the power steering pump go out three times. If you trap fluid with the gasket, you will have a leak that can only be fixed by dropping the pan again. You can drain the torque converter by turning the engine on for about three seconds. Identified numerous complaints online on duramax trans missions, and identified an aftermarket product was made to prevent further cracks from occurring.
The transmission will stick in one gear and will not shift. Limp mode is designed to keep the transmission from hurting itself when it detects something is wrong. When it goes out the steering and brakes fail and make it very hazardous to continue requiring me to stop and have some one pick up my truck and haul it home. Once the repair was made under warranty. Is he shooting me the bull? It seems that the housing is made of magnesium and is non similar metals. The panel on the drivers seat was warped. Feel free to contact us if you have any questions:.
Follow us on - - This site is not owned or operated by General Motors Company. When I took the truck in to cindy chevorlet I was told that per g. If you replentish the additives by replacing 50% of the fluid, you are further ahead. After five years, most of the issues with these trucks had been worked out. I don't believe they would have changed the housing to a different bolt hold configuration for the pan.